Go Back   The Navara Forum > D22 > D22 Engine

Reply
 
Thread Tools Display Modes

Engine Watchdog.
  #1  
Old 02-10-2018, 09:22 AM
Horatius Horatius is offline
Member
 
Join Date: Sep 2016
Location: Aus
Posts: 107
Default Engine Watchdog.

I recently installed a couple of gadgets to the old girl. One of these http://enginewatchdog.com/tm1.html to monitor temperature and one of these https://daviescraig.com.au/product/l...it-12-24v-1035 to warn of burst cooling hoses etc. Got 'em for roughly $130 each kit. Thought it was a good idea as I do a bit of remote area and off road travel.

There are plenty of different versions/brands of this type of sensor around, and it'll probably be of little interest to those with egt gauge, but I opted for one of these rather than a quality temperature gauge because of the alarm function (and it was probably cheaper than a quality gauge/sender). The other thing I like is that it bolts to the motor and measures the temperature of the metal rather than the coolant.

The low level alarm was a simple thing too. Simply cut and join it into the top radiator hose. It has a small float switch (guessing it is a reed type) similar (but smaller) to the one under the fuel filter. So no worries about electrolysis.

So far the highest temp reached is 86 deg C. That was putting the boot into it from about 80kph - 110 or more to get around traffic up a rather extended rise on the freeway. Though I also gave the radiator fins a good blow out with compressed air (releasing an awful lot of insects, grass seeds and dust lol). In normal driving it sits between 76-82 deg C. Have driven a bit of mountainous terrain loaded up and so far 85 deg is the highest. Though ambient temps haven't been that high yet.

I notice that at idle after warmed up it always finds it's way to 84 deg and sits there. Whether it's lower or higher than that when I stop. Sounds about right as the thermostat starts opening at 76.5 C and is fully open at 96 C according to the manual. I also notice that these things take a lot longer to warm up than the gauge indicates. The gauge says it's warm when it is in the early 40's and never moves after that. In reality, on a coolish day it can take well over half an hour for these things to reach operating temperature.

Would be interesting if anyone has an accurate gauge on their D22 (zd30) what temps they normally run at. The factory gauge has never wavered whether I'm trudging through sheeting snow or struggling up very steep 4wd tracks in 1st-2nd gear low range for hours on a 44 deg day. Simply gets to a bit under half and never moves. I get the feeling they are about as much genuine use as the "warning light" some cars have. Will be interesting to see what temps it really runs at.
Reply With Quote
Sponsored Links

  #2  
Old 02-10-2018, 10:19 AM
bods's Avatar
bods bods is offline
Advanced Member
 
Join Date: Sep 2010
Location: Orelia, WA
Posts: 4,726
Default

It is commonly referred to as the idiot gauge... I've used an OBD2 scantool and torque app on my android phone on my 2010 D22 and have noticed as you have said above. Normal range on the gauge is about 40c and it didn't move over its half way mark when the ecu was seeing coolant temp at 94c and displaying this through the torque app. That's the hottest I've seen mine, on the great central road near the end of January a couple of years ago. Aircon never stopped and from memory the highest intake temp I saw was around 46c when moving, didn't check to see what it got up to when stopped.

For the zd30, there are a couple of options for ecu reading tools. I believe the easiest one is the scangauge that has a small LCD screen and control panel that sits on the dash.

I think some of the guys on here have managed to get a phone app, Nissan data scan, working with an obd adaptor but the zd30 isn't fully OBD2 compliant, so the cheap generic ones won't work...

Sent from my moto g(6) plus using Tapatalk
Reply With Quote

  #3  
Old 01-11-2018, 01:51 AM
Horatius Horatius is offline
Member
 
Join Date: Sep 2016
Location: Aus
Posts: 107
Default

Recently had the old nav pumping along at 130kph in 40 deg against a strong wind for hours and noticed the temp climb to 95 deg. So I slowed down and watched it climb to 97 deg before slowly dropping back down to 88-92 deg range at 110-120 kph. Having a winch and lights mounted on the bullbar probably doesn't help with airflow.

I noticed the factory temp gauge hadn't moved at all through this. Stayed where it always does, a bit under half. Looks like they read "normal" at anywhere from mid 40's to 100deg. Wonder how hot is too hot for these things?

Last edited by Horatius; 01-11-2018 at 01:54 AM.
Reply With Quote

  #4  
Old 01-11-2018, 05:59 AM
bods's Avatar
bods bods is offline
Advanced Member
 
Join Date: Sep 2010
Location: Orelia, WA
Posts: 4,726
Default

Quote:
Originally Posted by Horatius View Post
Recently had the old nav pumping along at 130kph in 40 deg against a strong wind for hours and noticed the temp climb to 95 deg. So I slowed down and watched it climb to 97 deg before slowly dropping back down to 88-92 deg range at 110-120 kph. Having a winch and lights mounted on the bullbar probably doesn't help with airflow.

I noticed the factory temp gauge hadn't moved at all through this. Stayed where it always does, a bit under half. Looks like they read "normal" at anywhere from mid 40's to 100deg. Wonder how hot is too hot for these things?
I can only assume you haven't got an egt gauge? I'd be more concerned with the exhaust temperature once the coolant temperature starts rising. Coolant temp only gives you part of the picture. Once that starts rising, oil temp is also getting up there... I haven't got an oil temp gauge on mine, I do have boost, egt and oil pressure though. It is amazing how quick the egt goes up with these things when you work them hard.
Reply With Quote

  #5  
Old 01-11-2018, 09:07 AM
Rumpig's Avatar
Rumpig Rumpig is offline
Advanced Member
 
Join Date: Aug 2009
Location: Darwin
Posts: 1,536
Garage
Default

I just moved from Darwin to W.A , ute loaded up towing an enclosed trailer. Ecutalk showed 106 and the guage hadn't budged from it's normal postion of just under half. Didn't want to find out when it does move but i'm guessing 110.
__________________
"A little information is a dangerous thing"
Reply With Quote

  #6  
Old 07-11-2018, 01:48 AM
Boogieboots's Avatar
Boogieboots Boogieboots is offline
Member
 
Join Date: Jun 2016
Location: Byford WA
Posts: 235
My Mood:
Garage
Default

Well welcome to WA then Rum! You still up in the warm end or moved further south?
__________________
2005 d22 Dual Cab ZD30, 280k and counting....
Reply With Quote

  #7  
Old 08-11-2018, 07:50 AM
Rumpig's Avatar
Rumpig Rumpig is offline
Advanced Member
 
Join Date: Aug 2009
Location: Darwin
Posts: 1,536
Garage
Default

Halfway , Geraldton.
__________________
"A little information is a dangerous thing"
Reply With Quote

  #8  
Old 08-11-2018, 05:07 PM
bods's Avatar
bods bods is offline
Advanced Member
 
Join Date: Sep 2010
Location: Orelia, WA
Posts: 4,726
Default

Good old Gero haha. You're in for a windy time up there.

Sent from my moto g(6) plus using Tapatalk
Reply With Quote

  #9  
Old 09-11-2018, 05:02 AM
Rumpig's Avatar
Rumpig Rumpig is offline
Advanced Member
 
Join Date: Aug 2009
Location: Darwin
Posts: 1,536
Garage
Default

I can take up hangliding again. Not enough wind for hangliding i'll go diving instead.
__________________
"A little information is a dangerous thing"
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump



All times are GMT +1. The time now is 08:01 AM.



Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2018, vBulletin Solutions, Inc.
| Home | Register | FAQ | Members List | Calendar | Today's Posts | Search | New Posts |