Recent content by reel-sensation

Hi What I did with mine was I used a vernier on the original cable to get the size and then visited a motorcycle shop and got a clutch or brake cable and bodgied one up. No need to remove the outer cable that way. Just have to make a new nipple on the cable at the pedal end. Alan

Hi On my QD it was the throttle lever on the injector pump had worn the round hole to an oval hole in the top cover and was letting in air. The throttle lever is the one connected to the throttle cable. Cost me $200 for new cover. Alan

Hi Christian, The snorkel I used was for a ZD30 and it sits higher so you don't have to move the blinker down. Also the big hole is only half way along guard with a connecting piece inside the guard. With my exhaust, I took out the front resonator box. Alan

Hi Christian, Good job with the turbo. You will love it. I have a QD32. How much was the Zordo kit? That is my next plan. Also you will need a catch can on the PCV hose. Alan

Had mine fixed in Brissy. They just replaced the top cover of the pump cause the throttle shaft had worn the hole to an oval shape. Cost was around $200 fitted. Alan

Hi, Try undoing uni joint and turning it a half turn and re-install. Sometimes this can fix a vibration in drive shaft and doesn't cost anything. Alan

Sorry! I take it all back! I only know from SIMILAR Chinese campers that I have seen. Alan

Hi, I build quality campers as my job. MDC/GIC are Chinese. If you are considering a hard floor: 1. Check canvas fit. All MDC hard floor campers I have seen, the canvas is badly fitted and saggy. In windy/rainy weather the window flaps allow rain and wind to enter. Also it takes a while to fully...

Hi You can also pull your alternator apart and solder a wire on (any) one of the windings in the case. This will provide a pulse. Alan

By lengthening the outer cable with the adjuster, you are taking the slack out of the inner cable. With mine, I used a motorcycle inner brake cable. I just measured the thickness with a vernier and got one the same. Nissan wanted the equivalent of a left testicle for the part. You could try a...

Hi guys, There is a cable adjuster down on/near the fuel pump. Mine was the same but mine was almost worn right through. With fuel consumption, if you try to hang on to 100kph on the highway you will chew through the fuel pretty quick. Keeping the revs to below 2500 will give you better...

Hi Dan Looks good! Get a turbo on it. You wont be disappointed. Alan

Hi Pretty sure it has timing gears, same as qd32. Down load and have a look at the electronic manual. Alan

When you lifted one wheel and turned it, was it in neutral? It will only lock when in gear (if the LSD is ok). Alan